Thorium was successfully used as an alternative nuclear fuel to uranium in the molten-salt reactor experiment (MSR) from 1964 to 1969 to produce thermal energy, as well as in several light-water reactors using fuel composed of a mixture of 232Th and 233U, including the Shippingport Atomic Power Station (operation commenced 1957, decommissioned in 1982). Currently, officials in the Republic of India are advocating a thorium-based nuclear program, and a seed-and-blanket fuel utilizing thorium is undergoing irradiation testing at the Kurchatov Institute in Moscow. Advocates of the use of thorium as the fuel source for nuclear reactors state that they can be built to operate significantly cleaner than uranium based power plants as the waste products are much easier to handle.
Pure thorium is a silvery-white metal which is air-stable and retains its luster for several months. When contaminated with the oxide, thorium slowly tarnishes in air, becoming gray and finally black. The physical properties of thorium are greatly influenced by the degree of contamination with the oxide. The purest specimens often contain several tenths of a percent of the oxide. Pure thorium is soft, very ductile, and can becold-rolled, swaged, and drawn. Thorium is dimorphic, changing at 1400 °C from a face-centered cubic to a body-centered cubic structure. Powdered thorium metal is often pyrophoric and requires careful handling. When heated in air, thorium metal turnings ignite and burn brilliantly with a white light. Thorium has the largest liquid range of any element: 2946 °C between the melting point and boiling point.
Thorium is slowly attacked by water, but does not dissolve readily in most common acids, except hydrochloric. It dissolves in concentrated nitric acid containing a small amount of catalytic fluoride ion.
Thorium compounds are stable in the +4 oxidation state.
Thorium(IV) nitrate and thorium(IV) fluoride are known in their hydrated forms: Th(NO3)4·4H2O and ThF4·4H2O, respectively. The thorium center has square planar geometry. Thorium(IV) carbonate, Th(CO3)2, is also known.
Thorium(IV) hydroxide, Th(OH)4, is highly insoluble in water, and is not amphoteric. The peroxide of thorium is rare in being an insoluble solid. This property can be utilized to separate thorium from other ions in solution.
Thorium monoxide has recently been produced through laser ablation of Thorium in the presence of oxygen
Naturally occurring thorium is composed mainly of one isotope: 232Th. 230Th occurs as the daughter product of 238U decay. Twenty-seven radioisotopes have been characterized, with the most stable being 232Th with a half-life of 14.05 billion years, 230Th with a half-life of 75,380 years, 229Th with a half-life of 7340 years, and 228Th with a half-life of 1.92 years. All of the remaining radioactive isotopes have half-lives that are less than thirty days and the majority of these have half-lives that are less than ten minutes. One isotope, 229Th, has a nuclear isomer (or metastable state) with a remarkably low excitation energy of 7.6 eV.
Applications of thorium:
- Thorium is used as an alloying element in magnesium, used in aircraft engines, imparting high strength and creep resistance at elevated temperatures. Thoriated magnesium was used to build the CIM-10 Bomarc missile, although concerns about radioactivity have resulted in several missiles being removed from public display.
- Thorium is also used as an alloying agent in gas tungsten arc welding (GTAW) to increase the melting temperature of tungsten electrodes and improve arc stability. The electrodes labeled EWTH-1 contain 1% thorium, while the EWTH-2 contain 2%.
- Thorium is used to coat tungsten wire used in electronic equipment, improving the electron emission of heated cathodes.
- Uranium-thorium age dating has been used to date hominid fossils.
- Thorium is used as a fertile material for producing nuclear fuel. In particular, the proposed energy amplifier reactor design would employ thorium. Since thorium is more abundant than uranium, some nuclear reactordesigns incorporate thorium in their fuel cycle.
- Thorium may also be used directly as nuclear fuel instead of uranium, producing less transuranic waste.
- Thorium is a very effective radiation shield, although it has not been used for this purpose as much as lead or depleted uranium.
Applications of thorium dioxide (ThO2):
- Mantles in portable gas lights. These mantles glow with a dazzling light (unrelated to radioactivity) when heated in a gas flame.
- Used to control the grain size of tungsten used for electric lamps.
- Used in heat-resistant ceramics like high-temperature laboratory crucibles.
- Added to glass, it helps create glasses of a high refractive index and with low dispersion. Consequently, they find application in high-quality lenses for cameras and scientific instruments.
- Has been used as a catalyst:
- Thorium dioxide is the active ingredient of Thorotrast, which was used as part of X-ray diagnostics. This use has been abandoned due to the carcinogenic nature of Thorotrast.
Thorium as a nuclear fuel
Thorium, as well as uranium and plutonium, can be used as fuel in a nuclear reactor. A thorium fuel cycle offers several potential advantages over a uranium fuel cycle, including greater abundance on Earth, superior physical and nuclear properties of fuel, enhancedproliferation resistance, and reduced nuclear waste production.
Although not fissile itself, 232Th will absorb slow neutrons to produce 233U, which is fissile. Hence, like 238U, it is fertile. It is at least 4-5 times more abundant in Earth's crust than all isotopes of uranium combined and is fairly evenly spread around Earth, with many countries having large supplies of it. Also, preparation of thorium fuel does not require a isotopic separation.
The thorium fuel cycle creates Uranium-233, which can be used for making nuclear weapons – and since there are no neutrons from spontaneous fission of U-233, U-233 can be used easily in a simple gun-type nuclear bomb design. In 1977 a light-water reactor at the Shippingport Atomic Power Station was used to establish a Th232-U233 fuel cycle. The reactor worked until its decommissioning in 1982. Thorium can be and has been used to power nuclear energy plants using both the modified traditionalGeneration III reactor design and prototype Generation IV reactor designs.
A seed-and-blanket fuel using a core of plutonium surrounded by a blanket of thorium/uranium has been undergoing testing at Moscow's Kurchatov Institute, under a 1994 agreement between the institute and McLean, Virginia-based Thorium Power Ltd. Russian government-owned nuclear design firm Red Star formed an agreement with Thorium Power in 2007 to continue work on scaling up the test fuel rods to commercial use and licensing in VVER-1000 reactors. This assembly could achieve a more efficient disposal method of weapons-grade plutonium than the mixed-oxide disposal method, especially with the 2009 decision by the US to shelve the Yucca Mountain nuclear waste storage program highlighting the issue of what to do with all the plutonium left over from decommissioned nuclear weapons. Thorium Power, with offices in London, Dubai, and Moscow and with Dr. Hans Blix serving as an advisor, also advises the United Arab Emirates on their fledgling nuclear program. They are awaiting the finalization of the US-India nuclear 1-2-3 Agreement to complete a joint-venture with Punj Lloyd, an Indian engineering firm with nuclear reactor construction ambitions.
When using thorium in modified light water reactor (LWR) problems include: the undeveloped technology for fuel fabrication; in traditional, once-through LWR designs potential problems in recycling thorium due to highly radioactive 228Th; some weapons proliferation risk due to production of 233U; and the technical problems (not yet satisfactorily solved) in reprocessing. Much development work is still required before the thorium fuel cycle can be commercialized for use in LWR. The effort required has not seemed worth it while abundant uranium is available, but geopolitical forces (e.g. India looking for indigenous fuel) as well as uranium production issues, proliferation concerns, and concerns about the disposal/storage of radioactive waste are starting to work in its favor. In 2008, Senator Harry Reid (D-Nevada) and Senator Orrin Hatch (R-Utah) introduced the Thorium Energy Independence and Security Act of 2008, which would mandate a US Department of Energy initiative to examine the commercial use of thorium in US reactors. The bill, however, did not reach a full Senate vote.
The thorium fuel cycle, with its potential for breeding fuel without fast neutron reactors, holds considerable potential long-term benefits. Thorium is significantly more abundant than uranium, and is a key factor in sustainable nuclear energy. Perhaps more importantly, thorium produces one to two orders of magnitude less long-lived transuranics than uranium fuel cycles, though the long-lived actinide protactinium-231 is produced, and the amount of fission products is similar..
An early effort to use a thorium fuel cycle took place at Oak Ridge National Laboratory in the 1960s. An experimental reactor was built based on MSR technology to study the feasibility of such an approach, using thorium-fluoride salt kept hot enough to be liquid, thus eliminating the need for fabricating fuel elements. This effort culminated in the Molten-Salt Reactor Experiment that used 232Th as the fertile material and 233U as the fissile fuel. This reactor was operated successfully for about five years. However, due to a lack of funding, the MSR program was discontinued in 1976. Nowadays this design is considered as Generation IV reactor.
India's Kakrapar-1 reactor is the world's first reactor which uses thorium rather than depleted uranium to achieve power flattening across the reactor core. India, which has about 25% of the world's thorium reserves, is developing a 300 MW prototype of a thorium-based Advanced Heavy Water Reactor (AHWR). The prototype is expected to be fully operational by 2011, following which five more reactors will be constructed. Considered to be a global leader in thorium-based fuel, India's new thorium reactor is a fast-breeder reactor and uses a plutonium core rather than an accelerator to produce neutrons. As accelerator-based systems can operate at sub-criticality they could be developed too, but that would require more research. India currently envisages meeting 30% of its electricity demand through thorium-based reactors by 2050.
M. T. Esmark found a black mineral on Løvøy Island, Norway and gave a sample to Professor Jens Esmark, a noted mineralogist who was not able to identify it, so he sent a sample to the Swedish chemist Jöns Jakob Berzelius for examination in 1828.Berzelius analyzed it and named it after Thor, the Norse god of thunder. The metal had virtually no uses until the invention of the gas mantle in 1885.
In 1898 thorium was first observed to be radioactive, independently, by Polish-French physicist Marie Curie and English chemist Gerhard Carl Schmidt. Between 1900 and 1903, Ernest Rutherford and Frederick Soddy showed how thorium decayed at a fixed rate over time into a series of other elements. This observation led to the identification of half life as one of the outcomes of the alpha particle experiments that led to their disintegration theory of radioactivity.
The name ionium was given early in the study of radioactive elements to the 230Th isotope produced in the decay chain of 238U before it was realized that ionium and thorium were chemically identical. The symbol Io was used for this supposed element.
Thorium is found in small amounts in most rocks and soils, where it is about four times more abundant than uranium, and is about as common as lead. Soil commonly contains an average of around 12 parts per million (ppm) of thorium. Thorium occurs in several minerals including thorite (ThSiO4), thorianite (ThO2 + UO2) and monazite. The latter is most common and may contain up to about 12% thorium oxide. Thorium-containing monazite(Ce) occurs in all continents.
232Th decays very slowly (its half-life is comparable to the age of the Universe) but other thorium isotopes occur in the thorium and uranium decay chains. Most of these are short-lived and hence much more radioactive than 232Th, though on a mass basis they are negligible.
Thorium has been extracted chiefly from monazite through a complex multi-stage process. The monazite sand is dissolved in hot concentrated sulfuric acid (H2SO4). Thorium is extracted as an insoluble residue into an organic phase containing an amine. Next it is separated or "stripped" using an ion such as nitrate, chloride, hydroxide, or carbonate, returning the thorium to an aqueous phase. Finally, the thorium is precipitated and collected.
Several methods are available for producing thorium metal: it can be obtained by reducing thorium oxide with calcium, by electrolysis of anhydrous thorium chloride in a fused mixture of sodium and potassium chlorides, by calcium reduction of thorium tetrachloride mixed with anhydrous zinc chloride, and by reduction of thorium tetrachloride with an alkali metal.
Present knowledge of the distribution of thorium resources is poor because of the relatively low-key exploration efforts arising out of insignificant demand. There are two sets of estimates that define world thorium reserves, one set by the US Geological Survey (USGS) and the other supported by reports from the OECD and the International Atomic Energy Agency (the IAEA). Under the USGS estimate, Australia and India have particularly large reserves of thorium. India and Australia are believed to possess about 300,000 metric tonnes each; i.e. each country possessing 25% of the world's thorium reserves. However, in the OECD reports, estimates of Australian's Reasonably Assured Reserves (RAR) of Thorium indicate only 19,000 metric tonnes and not 300,000 tonnes as indicated by USGS. The two sources vary wildly for countries such as Brazil, Turkey, and Australia. However, both reports appear to show some consistency with respect to India's thorium reserve figures, with 290,000 metric tonnes (USGS) and 319,000 metric tonnes (OECD/IAEA). Furthermore the IAEA report mentions that India possesses two thirds (67%) of global reserves of monazite, the primary thorium ore. The IAEA also states that recent reports have upgraded India's thorium deposits up from approximately 300,000 metric tonnes to 650,000 metric tonnes. Therefore, the IAEA and OECD appear to conclude that Brazil and India may actually possess the lion's share of world's thorium deposits.
- The prevailing estimate of the economically available thorium reserves comes from the US Geological Survey, Mineral Commodity Summaries (1997–2006):
|Country||Th Reserves (tonnes)||Th Reserve Base (tonnes)|
Note: The OECD/NEA report notes that the estimates(Australian figures are based on) are subjective as a result of the variability in the quality of the data, a lot of which is old and incomplete. A more recent estimate of 489,000 metric tonnes has been published by Geoscience Australia(2009); identified resources refer to RAR plus inferred resources recoverable at less than US$80/kg Th.
- Another estimate of Reasonably Assured Reserves (RAR) and Estimated Additional Reserves (EAR) of thorium comes from OECD/NEA, Nuclear Energy, "Trends in Nuclear Fuel Cycle", Paris, France (2001):
|Country||RAR Th (tonnes)||EAR Th (tonnes)|
Dangers and biological roles
Powdered thorium metal is pyrophoric and will often ignite spontaneously in air. Natural thorium decays very slowly compared to many other radioactive materials, and the alpha radiation emitted cannot penetrate human skin meaning owning and handling small amounts of thorium, such as a gas mantle, is considered safe. Exposure to an aerosol of thorium can lead to increased risk of cancers of the lung, pancreas and blood, as lungs and other internal organs can be penetrated by alpha radiation. Exposure to thorium internally leads to increased risk of liver diseases.
The element has no known biological role.
The above information is taken from wikipedia (http://en.wikipedia.org/wiki/Thorium)